酒店智能自動隔油提升設備按照實際的安裝圖紙行，注意方向，間距等參數。同時要保持注意水平性。接著我們要檢查管道內有無滲漏情況。接通電源，此過程中要注意方向別接反了。在設備安裝完成后，先是接通地埋設備所有陪配套的自來水管和電線。

 1.操作人員應熟悉沉砂池除砂設備的構造及工作原理。2.確保電機電源線連接正確，供給電壓正常。3.開動沉砂池除砂設備前應檢查值班記錄和PLC控制柜的指示開關。4.寒冷天氣時，真空啟動裝置的管道系統中的水在使用后必須排干，防止結凍。5.撥“手動”檔位，槳葉驅動裝置與砂泵相互立運行，分別由相應的開關控制開停，逆時針轉動為開，順時針轉動為關，通常情況下，槳葉驅動裝置應連續運轉，砂泵及砂水分離器的工作時間在控制面板中設置;撥“自動”檔位，除砂系統內所有設備由槳葉驅動裝置開關控制開停，逆時針轉動為開，順時針轉動為關;撥“遠程”檔位，除砂系統內所有設備由中控室控制開停。除砂系統出現的故障排除后應按動“復位”按鈕，需要緊急停機時應按動“急停”按鈕。6.開動沉砂池除砂設備時操作人員應在旁觀察砂泵的振動和噪音情況，出現問題應立即關機。7.若要加大水有機物的分離，應適當調低槳葉的高度，若要加大砂粒及有機物的去除率，應適當調高槳葉的高度。8.每日監測出水的流速，確保在0.6~1.06m/s的允許值內。9.沉砂池集砂斗不應集砂過多，適宜的提砂周期為3~4小時。

1.對洗滌廢水、清洗廢水、甩干廢水這3種廢水行集中，確保工藝處理的廢水來源相對穩定。2.在洗衣廢水排入集中池時，增加格柵，用以除水中的短纖維和懸浮物。3.根據廢水水質選擇合適的絮凝劑行絮凝沉降，降低色度，去除懸浮物和些有雜質。4.通過對廢水的絮凝沉降后將上層清液行機械過濾，確保出水清澈透明。5.加化，殺，對機械過濾的出水步處理，以保證出水的水質達到回用水質指標。6.調節pH后，入清水蓄水池，可供洗衣7.檢查安全防護裝置是否完整、安全、靈活、準確、可靠。8.檢查潤滑裝置是否齊全、完整、可靠、油路暢通、油標醒目，對各種傳動部位行潤滑加油。9.檢查螺絲并行緊固處理，以防在使用中脫落；檢查傳動系統各操作手柄，電器開關位置正確無松動。10. 檢查設備的完好性及部件、配件是否缺失，各種工具、附件應擺放整齊，存放有序。11.檢查各種管線、管件是否完好，無跑、冒、滴、漏、滲現象。12.清潔設備各部位，使設備內外干凈，滑動導軌和接合處應無油污、銹跡、灰塵和雜物，做到漆見本色，鐵見光。

1.懸浮物的去除及分離般采用物理方法——主要通過格柵攔截、設置沉砂池等手段去除廢水中大塊懸浮物和砂粒等物質。污水中的無機顆粒和大直徑的有機顆粒靠自然沉淀作用就可去除，細小直徑及膠體有機顆粒靠微水解及生物降解作用去除，而小直徑的無機顆粒（包括尺度大小在膠體和亞膠體范圍內的無機顆粒）則要靠活性污泥絮體的吸附、網羅作用，與活性污泥絮體同時沉淀去除。出水懸浮物濃度不單涉及到出水SS指標，且出水的BOD5、COD等指標也與之有關。這是因為組成出水懸浮物的主要活性污泥絮體，其本身的有機成份就很高，因此較高的出水懸浮物含量會使得出水的BOD5、COD均增加。因此，控制污水廠出水的SS指標是zui基本的，也是很重要的。為了降低出水中的懸浮物濃度，在普通活性污泥法工藝中采取適當的措施，例如采用適當的污泥負荷以保持活性污泥的凝聚及沉降性能，采用較小的二次沉淀池表面負荷，采用較低的出水堰負荷，充分利用活性污泥懸浮層的吸附網羅作用等。在再生水回用處理工藝方案選用合理、工藝參數取值適當和單體設計優化的條件下，活性污泥法工藝*使出水SS指標達到20mg/L以下。2.有機污染物的可生化性分析污水中有機污染物主要以BOD5、COD表示，它們的去除主要是靠微生物的吸附作用和生物代謝作用，然后通過對泥水分離來完成的。活性污泥中的微生物在有的條件下將污水中的有機物用于合成新的細胞，將另有機物行分解代謝以便獲得細胞合成所需的能量，其zui終產物是CO2和H2O等穩定物質。在這種合成代謝與分解代謝過程中，溶解性有機物（如低分子有機等易降解有機物）直接入細胞內部被利用，而顆粒有機物則先被吸附在微生物表面，然后被酶水解后入細胞內部被利用。由此可見，微生物的好代謝作用對污水中的溶解性有機物和非溶解性有機物都起作用，并且代謝產物是無的穩定物質。因此，可以使處理后污水中的殘余BOD5濃度很低。

酒店智能自動隔油提升設備