別墅型衛生間污水提升器利用快速旋轉所產生的離心力將廢水中懸浮顆粒行分離。當含懸浮顆粒的廢水發生快速旋轉運動時，質量大的固體顆粒被甩到外圍，質量小的則留在內圈，從而使廢水與懸浮顆粒得到分離，廢水獲得凈化。

1.設備安裝前，必須夯實地基。并用混凝土砂漿墊高100-150mm。也可架空安裝，但基礎必須能承擔設備運行時的重量。2.設備就位后需調整水平。3.設備需設清洗用下水道，可挖明渠，也可直接采用管道接節池，以便沖洗氣浮池的水排出去。4.污水與反應池之間的聯接管道，要求越短越好，以免絮凝體在管道中被破壞。5.清水出口可接通下水道排放，如需入下道處理工序，可直接與下道處理設備相接。6.污泥出口可接泥槽或污泥處理設備。7.電器箱般應 放置在扶梯側面，環境應干凈、清潔。調試：A.設備調試前，應做好以下準備工作：1.要清洗水池內所有的贓物、雜物。2.對水泵及空壓機等需要潤滑部位行加油潤滑。3.按下刮沫機開關，使其向溶氣系統端行走。運行到頭后在行程撞塊作用下，刮沫機反向行走，直到污泥槽，行程撞塊將刮板翻起，按下停止按鈕，停止刮沫。B.試運行：1.加水：使氣浮機水位達到距污泥池隔板上沿約20-50mm，氣浮池水位的高低，可用集水器調節。2.溶氣系統運行：關閉所有控制閥，將電器旋鈕開關旋動位置，啟動水泵，此時空壓機也入自動工作狀態，然后順序打開舉清水泵水閥、出水閥、控制閥，壓力表壓力逐漸上升，般應達到0.4-0.5MPa。此時打開溶氣罐出水控制閥門，使溶氣水通過釋放器，釋放浮池內，氣浮池內出現大量的微細氣泡，使清水變成乳白色，溶氣系統即為正常，溶氣壓力越高，釋放的溶氣水泡密度越高。溶氣系統的氣體由空壓機提供。由于溶氣水不斷將罐內空氣帶走，罐內空氣逐漸減少，水位上升。當水位上升到定位置時，浮球液位計將控制空壓機工作，使罐內有足夠的空氣量。3.氣浮運行：溶氣系統運行正常后，將加反應后的污水送浮混合池。流量先小些，正常后逐漸增加穩定值。4.溶氣水：溶氣水先用自來水作回流水，正常后，改用處理后的清水作回流水。如廢水中洗滌劑量大，泡沫多，影響氣浮效果，可直用清水。5.浮渣積聚到定厚度后，啟動刮沫機。6.設備停機時，應先關閉污水控制閥，再關閉污水泵，將沫刮凈，停刮沫機，然后打開清水閥，通入自來水運行30分鐘，關閉溶氣出水水控制閥，停清水泵。

1.出水水質穩定由于膜的分離作用，分離效果遠好于傳統沉淀池，處理出水其清澈，懸浮物和濁度接近于零，和被大幅去除，可以直接作為非飲用市政雜用水行回用，用途較廣。同時，膜分離也使微生物被*被截流在生物反應器內，使得系統內能夠維持較高的微生物濃度，不但提高了反應裝置對污染物的整體去除效率，保證了良好的出水水質，同時反應器對水負荷（水質及水量）的各種變化具有很好的適應性，耐沖擊負荷，能夠穩定獲得的出水水質。2.剩余污泥產量少該工藝可以在高容積負荷下運行，次剩余污泥產量低（理論上可以實現零污泥排放），降低了污泥處理費用。3.占地面積小，不受設置場合限制生物反應器內能維持高濃度的微生物量，處理裝置容積負荷高，占地面積大大節省；該工藝流程簡單、結構緊湊、占地面積省，不受設置場所限制，適合于任何場合，可做成地面式、半地下式和地下式。4.操作管理方便，易于實現自動控制該工藝實現了水力停留時間，運行控制更加靈活穩定，是污水處理中容易實現裝備化的新技術，可實現微機自動控制，從而使操作管理更為方便。5.無需行深度處理。

別墅型衛生間污水提升器