全自動地下室污水提升裝置安裝水泵前應仔細檢查泵流道內有無影響水泵運行的硬質物，（如石塊、鐵砂等）以免水泵運行時損還過流部件；

1.安裝時管路重量不不應承受在泵上，否則易損環水泵；2.泵瑟電機是整體結構，出廠時已由廠家校正，所以安裝時無需調整，因此安裝時十分方便；3.安裝必須擰緊地腳螺栓，且每間隔事實上時段應對泵過行檢查防止其松動，以免水泵起動時發生劇烈振動而影響的性能；4.為了維修方便和使用安全，在泵的出口管路上安裝只調節閥及在泵出口附近安裝只壓力表，對于高揚程，為了防止水錘，還應在出口閘閥前安裝只止回閥以應付突然斷電等失去動力事故，從而確保水泵在工況下運行，增長水泵的使用壽命；5.泵用于有吸程場合，應裝有底閥，并且管路不應有過多彎道，同時不得有漏水、漏氣現象，以免影響水泵的吸入性能；6.為不使雜質入泵內而堵塞流道影響性能，應在泵前面安裝過濾器；7.安裝管路前轉動水泵的轉子部件，應無磨擦聲或卡死現象，否則應將泵拆開檢查原因。8.每次使用別是用于較稠較粘的漿液后，應將電泵放入清水中運轉數分鐘，防止泵內留下沉積物，保證電泵的清潔。9.電泵如長時間不用時應將電泵從水中取出，不要長期浸泡在水中，以減少電機定子繞組受潮的機會，增加電泵的使用壽命。 ^10.葉輪和泵體之間的密封環具有密封功能，如密封損壞將直接影響到泵的性能，必要時應更換。

1.出口處恒壓控制法把壓力傳感器放在統管道泵出水口，量出水口位置水.壓，控制過程簡單易行。然而，水在整個管網中流動的過程中存在管道損耗，而且管道不同折特點或者端特點處的情況總會存在些許差異，無法保證某些異特點的恒壓要求。2.出口處變壓控制方法同上面A方法樣將壓力傳感器放在水泵出水口，將整個給水時間劃分為幾個時間段，每個時間段的壓力，據該段時間范圍內用水量的大小來確定，在該時間段范圍內實現恒壓控制，在系統整個調控壞節中變壓調控。如果能夠充分調查供水對象的需水性,則可以設計出非常高效節能的控制系統,只是先期工作量較大,編程復雜。3.控制方法把壓力傳感器放在整個系統內供水不利特點，使包括不利特點在內整個管道范圍內都能滿足供水。

全自動地下室污水提升裝置